It should be down to 12.8 or below and should remain constant. You should see the isolator light turn off. ) You will hear a light humming noise once it stops your isolator should cut off. CERTIFIED SAFE: Unlike other isolators on the market, the KeyLine Automatic 140 Amp Dual Battery Isolator is IP65 Certified. While the engine is running, it automatically isolates the batteries so that the main battery is charged first. You can isolate your two battery banks with a battery isolator or a DC to DC charger depending on your system needs and preferences. Mine was charging around 13.9Īfter this, make sure that the isolator cuts off by turning the car off and turning the head lights on for a sec (to speed up the process otherwise you have to wait till the volts drop below 12.8 and the isolator will stop charging. The KeyLine Automatic 140 Amp Dual Battery Isolator is IP65 Certified. The isolator has two output poles, one connected to the main battery (and thus to the alternator) and one connected to the auxiliary battery. An isolating unit will disconnect the line between the batteries so that your lithium batteries do not continuously feed power into your starting battery. Use a volt meter to check that the battery voltage is above what it was when you first checked your ground connection. Start the car and check to see that the light is on and the isolator is sending power. So, I used a vice and it worked great.Ĭonnect all your inline fuses to your wires.Ĭonnect the isolator ground, then starter battery terminals, and last, connect the auxiliary battery terminals.Ĭonnect the ground terminal back on the starter battery. I didn't have a crimper for the large terminals. Strip, crimp, and heat shrink your wires, with the provided terminals. The other positive will run from the isolator to the auxiliary battery. You need one positive wire running from your Isolator to your starter battery. Get 2 x 100 Amp inline fuses either here from Amazon or at your local car stereo store. item 4 KeyLine Chargers Dual Battery Kit Isolator Voltage Sensitive Relay 12V 140 Amp KeyLine Chargers Dual Battery Kit Isolator Voltage Sensitive Relay 12V 140 Amp. Check by putting it in two different grounds and checking a volt meter to see if the volts remain the same. Make sure you have a solid ground connection on your auxiliary battery. Wont rob precious power from your batteries and. For once, a convenient placement for battery right at arms reach under the driver seat. KeyLine Chargers 140amp Battery Isolator is the best value battery charger on the market. This seems like a daunting task but it’s actually quite easy and I enjoyed learning along the way. I recommend it for the amount of wire they give you alone. I bought the Keyline Dual Battery Isolator on Amazon. The Keyline dual battery ATV/UTV Isolator is the only SMART unit designed with cutting edge programming to deliver optimum performance - with ZERO sacrifice. An isolator basically sends a charge to the auxiliary battery, from the alternator, after the starter battery is charged. A great way to charge dual batteries while on the road is through a battery isolator.
0 Comments
Leave a Reply. |